Vehicle-Specific Installation Notes

Rain Tracker Model: RT-40A
Vehicle-Specific Installation Instructions
The instructions included with the product tell you how to install a Rain Tracker. This page gives special vehicle-specific information. Print this page using your browser's print function.

Application Vehicles
These instructions apply to these vehicles, which all have similar wiper systems:

FORD CROWN VICTORIA 03 - 07
FORD TAURUS 04 - 07
FORD-TRUCK PICKUP F-250, F-350, F-450, F-550, SUPERDUTY 02 - 07
FORD-TRUCK EXPEDITION 03 - 06
FORD-TRUCK EXCURSION 02 - 05
FORD-TRUCK ECONOLINE VAN E-150, E-250, E-350, E-450 05 - 10
LINCOLN NAVIGATOR 03 - 06
LINCOLN TOWN CAR 03 - 07
MERCURY SABLE 04 - 05
MERCURY MARAUDER 03 - 04
MERCURY GRAND MARQUIS 03 - 07

Wiring Diagrams and Drawings:

Ford Binary Wiper Systems, Color Scheme 2- Drawing applies to all application vehicles listed above. Print this.
Troubleshooting procedure- Print if needed.

Wire colors used in this vehicle:

+12V - LOCATE
GROUND - BLK or BLK/LT-GRN
LOGIC-A - DK-BLU/ORN
LOGIC-B - RED
LOGIC-C - YEL/RED
LOGIC-D - WHT

External Components Required for this installation

DIODE - 1N4004 - OR SIMILAR RECTIFIER
DIODE - 1N4004 - OR SIMILAR RECTIFIER

Special Rain Tracker Installation Notes for this vehicle:

Use the instructions included in the Rain Tracker kit until you get to step 5a. "Make the interface
connections." At that point, use these instrctions along with the diagram that can be printed above.
Return to the general instructions when the interface connections has been completed.

Some models and years may vary slightly in wire colors. Confirm wire colors with service
guide, and/or with with a multimeter.

All wiper system wires, except +12V, are available at the wiper switch. They
can usually be accessed by removing one or two access panels (Kick Panels) and,
possibly, the shrouds surrounding the steering column.

FIND +12V
For Rain Tracker power (+12V), locate a source of power hot in accessory
or run. Power source should be min. 12-16ga. wire on a 15-25A circuit. This
can be one of the +12V sources as shown on the diagram, or some other accessory
source. The cigarette lighter is often a good +12V source.

2009 - 2010 FORD ECONOLINE VAN
We do not know the exact wire colors for the Ford Econoline Series for 2009 and 2010. We received a diagram for the 2011 from a customer and it shows Ford Binary Color Scheme 7 (C7). Since this is the case the wiper system will be the same for 09 - 10 but the colors could be different. If the colors for the 2009 or 2010 do not match these instructions, please see Ford Binary Color Scheme 7

The RT-40A does not utilize the FAST windings of the wiper motor. Please disregard any references
to FAST that appear in these instructions.

The Rain Tracker wiper control system works in parallel with the existing wiper system, so the existing manual control modes are not affected. This page generated by vehicle data file name: ford_binary_c2.veh